{"id":1618,"date":"2008-08-11T11:46:08","date_gmt":"2008-08-11T15:46:08","guid":{"rendered":"http:\/\/tour.airstreamlife.com\/wordpress\/?p=1618"},"modified":"2008-08-11T11:46:08","modified_gmt":"2008-08-11T15:46:08","slug":"straightening-things-out","status":"publish","type":"post","link":"https:\/\/tour.airstreamlife.com\/wordpress\/?p=1618","title":{"rendered":"Straightening things out"},"content":{"rendered":"

Things start early at the service center . \u00a0 At 7 a.m., anyone who is ready to go will get hitched up to a green John Deere tractor and hauled into a service bay — it’s first-up, first served. \u00a0 We rushed around to get all four of us up and out, and when we were more or less dressed, I went over to the service desk to tell them we were ready. \u00a0 Two minutes later, the tractor was hitching up.<\/p>\n

\"jc-bumper-compartment.jpg\"<\/a>I knew we were going to face some heavy expenses related to the scrape I had last January<\/a> on the way to Quartzsite, and the recent bumper tweaking in New York. \u00a0 The guys here felt that the bumper would be hard to straighten, in addition to needing welding, and probably would never be quite right again. \u00a0 After considering options, I finally decided to go with a new bumper ($337 – ouch). \u00a0 The old bumper, covered with irreplaceable stickers that memorialize our travels, will be shipped to our home base for permanent display in the garage. \u00a0 In the photo at right you can see what an Airstream looks like without any bumper at all.<\/p>\n

The other repairs planned were relatively minor. \u00a0 We had the replacement valve stem on the tire that went flat yesterday, bending the rear scrapers straight again, replacing some trim and the bumper compartment cover ($79), and the Dometic refrigerator recall kit (free). But there was a surprise as well.<\/p>\n

\"jc-bad-rotor.jpg\"<\/a><\/p>\n

When the tech took off the spare tire we had hurriedly put on by the side of the highway yesterday, they saw that the disc brake rotor was completely shot. \u00a0 The disc brakes have inner and outer brake pads, which are supposed to slide on a bolt so that they both apply evenly and wear evenly. \u00a0 This particular set of pads seized up so that only the outer pad was wearing, and it wore out so completely that it scraped the rotor beyond repair.<\/p>\n

\"jc-jared-working.jpg\"<\/a>That added a lot to the repair list. \u00a0 We pulled all the other wheels off and found no similar problems, but the front axle’s disc brake pads were wearing more than the front, and it seemed time to replace those pads at least. \u00a0 I decided to replace all of the pads so we wouldn’t be doing this job again soon. \u00a0 The semi-metallic pads we have been using have lasted about 20,000 miles (not bad). \u00a0 This time we are installing ceramic pads, which should last even longer. \u00a0 So the bill has been increased by the cost of eight ceramic pads plus a complete hub\/rotor assembly. \u00a0 This is going to be an expensive day.<\/p>\n

Well, we’ve always tried to maintain the Airstream to a high standard. \u00a0 We have to, because we use it so much. \u00a0 I’d much rather do preventative maintenance here in Jackson Center than have to find some place along the way in an emergency.<\/p>\n

The good news is that the tires all look perfect. \u00a0 I was worried about losing another tire to belt breakage, since we’d had several failures of that type last year. \u00a0 So far, the wear looks good. \u00a0 Still, I’ve requested the service center to check the axle alignment before we go.<\/p>\n

As I write this the work is ongoing, so there may be more to it than I know right now. \u00a0 I’ll post another update tomorrow.<\/p>\n","protected":false},"excerpt":{"rendered":"

Things start early at the service center . \u00a0 At 7 a.m., anyone who is ready to go will get hitched up to a green John Deere tractor and hauled into a service bay — it’s first-up, first served. \u00a0 We rushed around to get all four of us up and out, and when we […]<\/p>\n","protected":false},"author":1,"featured_media":0,"comment_status":"open","ping_status":"closed","sticky":false,"template":"","format":"standard","meta":[],"categories":[13],"tags":[],"_links":{"self":[{"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=\/wp\/v2\/posts\/1618"}],"collection":[{"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=\/wp\/v2\/posts"}],"about":[{"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=\/wp\/v2\/types\/post"}],"author":[{"embeddable":true,"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=\/wp\/v2\/users\/1"}],"replies":[{"embeddable":true,"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=%2Fwp%2Fv2%2Fcomments&post=1618"}],"version-history":[{"count":0,"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=\/wp\/v2\/posts\/1618\/revisions"}],"wp:attachment":[{"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=%2Fwp%2Fv2%2Fmedia&parent=1618"}],"wp:term":[{"taxonomy":"category","embeddable":true,"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=%2Fwp%2Fv2%2Fcategories&post=1618"},{"taxonomy":"post_tag","embeddable":true,"href":"https:\/\/tour.airstreamlife.com\/wordpress\/index.php?rest_route=%2Fwp%2Fv2%2Ftags&post=1618"}],"curies":[{"name":"wp","href":"https:\/\/api.w.org\/{rel}","templated":true}]}}